抗硫化物应力腐蚀开裂试验报告模板.docx

《抗硫化物应力腐蚀开裂试验报告模板.docx》由会员分享，可在线阅读，更多相关《抗硫化物应力腐蚀开裂试验报告模板.docx（5页珍藏版）》请在得力文库 - 分享文档赚钱的网站上搜索。

1、检测报告Test Report报告编号Report No.样品名称Sample Name委托单位Entrustment Company试验项目Test Project样品名称 Sample Name钢管 Steel Pipe型号/规格Model and Specification60*10生产商Manufacturer Name/产品批号Product or Lot No.12003材质及状态Material and Condition20#炉批号Heat & Batch Number694587样品数量Sample quantity1样品编号 Sample No.JC220927001-1J

2、C220927001-2JC22092700I-3购买商 Buyer委托单位 Entrustment Company委托单位地址 Entrustment Company Address样品接收日期Sample Received Date2022-09-27试验周期Test Period2022-09-27 to 2022-10-31试验项目 Test Project抗硫化物应力腐蚀开裂试验Resistance to Sulfide Stress Corrosion Cracking Test试验标准Test standardGB/T 4157-2017试验结果 Test Result(s)无裂

3、纹No Cracks要求 Requirements无裂纹No Cracks结论Conclusion符合 Pass备注Remark要求由客户规定 Requirements are specified by client.(检验检测专用章)(Inspection and Testing Special Seal For)编制：审核：签发：Compiler:Auditor: Certifier:日期：日期：日期：Date:Date:Date:匿于以下任番一2情况的报告均为无效报缶：a）无“检笫检滤J专用目” ：b）报击有涂改；cj夏制报缶未击新加至“检蛤检测专用号” ：5无煽制、审核.转发人答字；c

4、）无典携餐。未 经委托单位书面司超.不得复制本报告的任何部分。委托检测仅对妄样负费.检测和判定依据报告中所述国冢或国际标准。若对检测报告持有异&.应于收到报告之日起15日内向恰 测单值提出.渝期不予处理。蜘：Add :服务树即el）: 试验项目：抗硫化物应力腐蚀开裂试验Test Project： Resistance to Sulfide Stress Corrosion Cracking Test 试验设备：JC-002体视显微镜TM45N/B5Test Equipment： JC-002 stcrconiicroscopc TM45N/B5校准日期:2022-10-22Calibratio

5、n date:2022-10-22试验环境：21.9/51%RHTest Environment： 21.9/51%RH试验步骤和条件：Test procedure &condition试验溶液Test SolutionA溶液Solution A加载方式Loading Mode四点弯曲法Four-Point Bending Method制样标准Sample preparation standardGB/T4157-2017脱脂方式Degrease Method丙酮Acetone取样位置和取样方向Sampling position and direction沿纵向方向Along the long

6、itudinal direction注：1、A溶液是质量分数为5%氯化钠及0.50%冰乙酸的蒸储水溶液；2、试验过程为：(1)制备试样；(2)放入试验容器；(3)配制溶液；(4)测初始溶液的pH：(5)以100ml/min/L的速度通氮气除氧两个小时；(6)以200ml/min/L的速度通入H2s至少1小时至溶液饱和；(7)维持H2s正压至试验结束；(8)试验终止时溶液的pH值；(9)试验结果检验。Note: 1. Solution A shall be 5.0wt%NaCI and 0.50wt% CH3coOH in distilled water.2.Test procedure: (1

7、) Preparation of specimens;(2) Test specimens shall be placed in the test vessel;(3) Solution preparation;(4) Measure the pH of initial solution;(5) Purge the test solution with nitrogen for at least two hours at a rate of 100ml /min per liter of test solution.(6) H2s gas shall be bubbled through th

8、e test solution for at least one hour at a rate of 200ml/min per liter of test solution.(7) Maintain H2s positive pressure until the end of (he experiment.(8) Measure the pH of test solution at the end of test.(9) Examine the test specimens after testing.试验结果：Test Result:匿于以下任番一2情况的报告均为无效报缶：a）无“检笫检滤

9、J专用目” ：b）报击有涂改；cj夏制报缶未击新加至“检蛤检测专用号” ：5无煽制、审核.转发人答字；c）无典携餐。未 经委托单位书面司超.不得复制本报告的任何部分。委托检测仅对妄样负费.检测和判定依据报告中所述国冢或国际标准。若对检测报告持有异应于收到报告之日起15日内向恰 测单值提出.渝期不予处理。蜘：Add :服务树即el）:试验结果Test Result试样编号Specimen Number加载应力(MPa) Loading stress (MPa)试验时间(h)Test DurationPH失效检查Failure Analysis初始溶液Initial Solution试验结束End

10、 of the TestJC220927001-01(1-1)208.257202.763.85无裂纹No CracksJC22092700I-02(1-2)208.257202.763.85无裂纹No CracksJC220927001-03(1-3)208.257202.763.85无裂纹No Cracks试验前后试样照片Photos of the specimens before/after the Test |川|阿 2 0141一一1叩1叩1即叫川中1业即11则1OQJ.06 08 0Z 09 os or oc 0试验前 Before the Test试验后 After the Te

11、st1工,Cz二.过心,我1建 翻JC220927001-01 20XJC220927001-02 20X匿于以下任番一2情况的报告均为无效报缶：a）无“检笫检滤J专用目” ：b）报击有涂改；cj夏制报缶未击新加至“检蛤检测专用号” ：5无煽制、审核.转发人答字；c）无典携餐。未 经委托单位书面司超.不得复制本报告的任何部分。委托检测仅对妄样负费.检测和判定依据报告中所述国冢或国际标准。若对检测报告持有异&.应于收到报告之日起15日内向恰 测单位猥出.海明不予处理。JC220927001-03 20X样品照片:Sample Photo:JC220927001*报告结束*End of repor

12、t*匿于以下任番一2情况的报告均为无效报缶：a）无“检笫检滤J专用目” ：b）报击有涂改；cj夏制报缶未击新加至“检蛤检测专用号” ：5无煽制、审核.转发人答字；c）无典携餐。未 经委托单位书面司超.不得复制本报告的任何部分。委托检测仅对妄样负费.检测和判定依据报告中所述国冢或国际标准。若对检测报告持有异&.应于收到报告之日起15日内向恰 测单位猥出.海明不予处理。Statement1、江苏精川材料检测研究有限公司(以卜一简称“本公司”)以保密的方法处理及卷发有关报告予客户。在未得本公司的同意除该报告不得作部分爱 制I,或作宣传或其它未经本公司许可的用途。当该客户从本公司收到有关报告后，可以展

13、示或传送该报告或由本公司所制定该报告的核证版本予其 顾客、供应商或其它直接有关人士。除非被有关政府机构、法律或法庭命令所要求，本公司在未经客户的同意前，将不会与其他方就报告的内容进 行任何讨论、可信的往来或透客,A report will be issued in confidence to (he Clients and it will be strictly treated as such by Jiangsu Jingchuan Material Testing Co.Ltd.(hereinafter referred to as“JSJC、)h should not be reprod

14、uced in part and i( should not be used fbr advertising or other unauthorized purposes without the written consent of JSJC.Thc Clients to whom the Report is issued,however.show or send it.or a certified copy thereof prepared by JSJC.lo his cuscomer,supplier or other persons directly conccrncd.JSJC wi

15、lLwithout the consent of the Clicnts.ncithcr enter into any discussion or correspondence with nor disclose to any other party concerning ihc contents of the reports unless required by the relevant governmental authorities,laws or court orders.2、除非本公司的确进行抽样试验及于有关报告内阐明此项事实，该报告只适用于已被试验的样品，而不适用于大量额度的有关货

16、品。Unless JSJC does cany oul a sampling test and clarify this fact in ihc relevant report.the report applies only to the samples that have been tested and do not apply to a large amount of the relevant goods.3、假若该客户并未指定该试验所应用的试验方法或标准，本公司将会自行选择适当的方法或标准并在委托协议/合同中告知，If the Clients do not specify (he mei

17、hods/standards to be applied.JSJC will choose (he appropriate methods/standards and inform the client in the agreenwnVcontract.4、当本公司收到该客户的请求，本公司可以以电子媒介传递有关试验服务的结果，但该客户应注意，电子媒介传递不能保证其所含资料不会流失、 延缓或被其他方截取。对于电r媒介传递导致其所含的任何资料出现泄漏、差误或遗漏，本公司将不会负任何责任。When JSJC receives the request from (he ClicntJSJC trans

18、mit the results of the test service in electronic mcdia.but the Client should note that the Electronic Media Delivery does not guarantee (hat (he inf(Kina(ion contained therein will not be lost,delayed or intercepted by third pariy.JSJC is not liable tor any disclosurc.crror or omission in the conte

19、nt of such messages as a result of electronic transmission.5、本公司对其可控范国之外发生的样品质量或其它特征的变化不承担责任。本报告不具有对试验项目或样品推荐或认可的作用.JSJC assumes no responsibiliiy for variations in quality or other characteristics of items submitted under conditions over which JSJC has no control.This Report docs not constitute a r

20、ecommendation fbr.or endorsement of.lhc item or material tested.6、报告涂改无效：无授权签字人签字无效：报告未加盖本公司”检验检测专用章”和崎继章无效.The report is invalid if altcrcd.or not signed by the authorized signatory.or without Special Seal fbr Inspection and Testing and without cross-page seal.7、对报告若有异议，有法律法规规定的，依照法律法规执行。其它委托类型报告应于

21、收到报告之日起卜五日内以竹面形式向本公司提出，逾期不予 受理。Any objection to the report should execute according to laws and regulations if cxist.olhcr entrusteti report should be submitted in written form to JSJC within 15 days from the date of receiving the report .and overdue will not be handled.8、样品及样品信息由客户提供及确认。本公司不负货证实样品的

22、真伪性，不承担证实客户提供信息的准确性、适当性和(或)完整性货任。The samplers) and sample information should be provided and confirmed by the Client.JSJC is not responsible for verifying the authenticity of the sample and does not assume responsibility fbr the accuracy, appropriateness and/or completeness of the information provid

23、ed by the Client.9、不包含CMA资质认定标志的报告，检测数据和结果仅供参考用，不作为社会公证性数据，中英文报告内容以中文为准.The date and results shown in the report without CMA logo can be only used fbr reference.not as notarial data for society.Tlie Chine” version of the report written in Chinese and English shall prevail.匿于以下任番一2情况的报告均为无效报缶：a）无“检笫检滤J专用目” ：b）报击有涂改；cj夏制报缶未击新加至“检蛤检测专用号” ：5无煽制、审核.转发人答字；c）无典携餐。未 经委托单位书面司超.不得复制本报告的任何部分。委托检测仅对妄样负费.检测和判定依据报告中所述国冢或国际标准。若对检测报告持有异应于收到报告之日起15日内向恰 测单值提出.渝期不予处理。蜘：Add :服务檄/Tel）: