生活污水处理站调试方案.doc

《生活污水处理站调试方案.doc》由会员分享，可在线阅读，更多相关《生活污水处理站调试方案.doc（5页珍藏版）》请在得力文库 - 分享文档赚钱的网站上搜索。

1、forming the Government, enterprises and the public forces and actively participate in, sharing a strong atmosphere. Comrades, do work in the countryside and five water treatment, three to split, is related to overall development, responsibility, task, departments at all levels must play more than sp

2、irit, do solid work, and difficult, and efforts to promote the work to a new level, South Gate of XX beauty to make new and greater contribution to the building! Research by the County, the County Government, the convening of this county, three, poverty and development, environmental protection, the

3、 main task is to 2016-these work arrangements. For a while, . . Gay also made an important speech, we must pay special attention to follow-up. The following, according to the citys plans and . . Comrade usual requirements of our work, I want to tell you three views: the first, on three last year, my

4、 County three has made certain achievements. Capital work is done using city funds . . Billion yuan, annual tasks . .%; only completion target . . Minutes, annual tasks . . rate, access to city-wide recruitment talent introduction . . Award recognized scientific and technological achievements . . ,

5、Cooperation of . . Innovation platforms . . Also complete tasks in the city. The overall three column in the city . . Name, did not enter the city in recognition of the results of this. This means we and other counties than there is room to continue the efforts. From each town in the County Street,

6、allocusing on ways and means of improving and upgrading work, further development of three to split. (A) fully grasp no unauthorised created. The township no unauthorised created the existing building one household, one document survey and file storage work must be unconditional and full coverage. M

7、ain corridor leading to the town (road, river) village, the Central built-up area of the town on both sides must be to create a no unauthorised village. According to five hundred villages created and shanty towns, villages, old houses, reconstruction of old plant, expand create, upgrading creates fi

8、les, the real no unauthorised village created into the benefit of the people of very good thing. (B) to strictly manage count as unauthorised controls. Promoting the new control work to move the center of gravity, management measures to the front, and earnestly pipes effectively. A strict new unauth

9、orised network responsibility. Sectors such as land, housing and basic stations (stations) and the Township of grid accountability mechanisms must be strictly in accordance with the new regulatory requirements, effective implementation of the area of responsibility of the new inspections, suppressio

10、n, demolition work to ensure that the new zero tolerance. Second, public security, water, electricity, water, oceans and fisheries, tourism collaboration, market supervision departments should strictly enforce the illegal construction of disposal of relevant provisions of the regulations, effective

11、fulfilment of responsibilities, particularly in electricity and water supply, and other units may not be new illegal buildings to supply water and electricity supply. While more regulation to prevent personal privacy violations. Illicit trading in illegal construction in the Ministry of public secur

12、ity sector to strictly from the blow. Three is to create additional offence reporting system of incentives. According to building law and covers an area of nature, to report timely degree divided report grade, effective after the removal of certain incentives. (C) integrated implementation , buildin

13、g demolition, modification, use combination. Demolition is the means and purpose built is. To adhere to the building demolished, combination of construction and demolition waste, demolished with combined efforts to improve the scientific level of three to split; second, we must pay attention to thre

14、e to split and five hundred and five water treatment, three of the four sides, the shackDistrict transformation, and dangerous old room transformation and two road sides, series work organic combined up, active do River, and along demolition work, and manpower advance village in the, and old residen

15、tial demolition work, to improved masses housing conditions and live environment; three to put three modified a split as traditional low, and small, and bulk industry structure transformation upgrade of important initiatives to caught, speed up advance industry Park, effective optimization park envi

16、ronment新柳生活污水处理站调试方案一、目 的（1）检验各个构筑物中的细部结构尺寸、闭水情况、熟悉各部位功能，测定构筑物及其设备性能；（2）检查各设备机组运转情况，并做好详细的检测记录。（3）对试车过程发现的存在问题逐一分析解决。二、范 围污水处理单元设备厂外格栅泵房格栅除污机 提升泵格栅间转鼓格栅鼓风机房鼓风机各种空气阀中间水池中间水泵各种阀门清水池各种水泵各种阀门三、空载试车（1）严格按照其设备说明及运行手册进行；（2）检查格栅安装尺寸、角度，开启格栅除污机进行空载试验，检查格栅空载运行情况；（3）检查水泵机组各处螺栓连接的完好程度，轴承中润滑油是否充足、干净，检查出水阀、压力表及真空

17、表上的阀门是否处于合适位置，供配电设备是否完好；（4）鼓风机空载试车严格按其运行手册进行，完毕后再与系统串联进行：打开 曝气 系统空气管路上的所有闸、阀门，首先逐台开启鼓风机，开启时先点动，后正式启动，记录各鼓风机运行参数，并检查空气管路各闸、阀门气密性。鼓风机进行并网试验，记录各鼓风机运行参数；四、负载试车1. 厂外泵站：将进水渠道和泵前池注满水，启动机械格栅，检查格栅运转情况，检查闸、阀门开启是否灵活，检查皮带输送机运转情况，启动进水泵，检查进水泵、止回阀（单向阀）是否运转正常，检查电磁流量计是否准确，检查格栅前后的液位差是否准确可靠，监测格栅、皮带输送机驱动电机的电流、电压以及轴温是否正

18、常；2. 生物反应池：向池中注水至淹没 曝气 头高度并打开供气干管供气阀门，先少量打开生化反应池布气管路调节阀门。此时，开一台鼓风机，向反应池供气，根据 曝气 情况，逐个池子调整 曝气 量，然后继续向反应池注水，并逐渐开大空气管路调节阀，在生化反应池不同液位下，检查 曝气 情况是否均匀。直至进水达到反应池设计水位，检查生化反应池池体有无渗漏，并开启 厌氧 搅拌器、缺氧搅拌器在清水中运行状况，开启混合液回流泵和污泥回流泵，检查各台回流泵工作状况，检查反应池各闸、阀门是否严密不漏水；五、调试过程常见问题与处理方案1. 机电设备类：编号设备类型故障现象可能原因处理措施1电机1无法启动无电源或接线脱落

19、检查电源及线路2运行中电流过小或过大负载端故障检查负载情况3温升过大轴承或负载过大检查轴承或负载端4噪音明显基础不牢固；轴承问题；负载端故障加固固定装置；检查轴承；检查负载端5转向错误电源三相调乱调整相序6运行中电压升高电源故障，负载端故障检查电源或负载端2螺旋细格栅除污机1走动轮在导轨内卡住轴承故障检查轴承2整机抖动基础或紧固螺栓不牢固加固基础；拧紧紧固螺栓3冲洗水压力不足水压不足增大水压，调节阀门3螺旋输送机1桨叶与槽体发生卡阻传动杆偏移调整桨叶位置2传动过程有抖动基座不牢固紧固基座3渣料外溢接口未能对上调整接口位置2机壳过热在调节阀关闭情况下长时间运转停机冷却或打开调节阀降温3风机振动基

20、础不牢固；连轴器故障；叶轮故障加固基座；调整连轴器；修理叶轮2. 泵类：故障现象可能原因处理措施启动后水泵不输水1吸水管路不严密，有空气漏入检查吸水管路2泵内未灌满水，有空气存在重新灌水，开启放气门3水封水管堵塞，有空气漏入检查和清洗水封水管4安装高度太高提高吸水池水位或降低水泵和水井水面间的距离5电动机转速不够检查电源电压和周波是否降低6电动机旋转方向相反调整相序7叶轮及出水口堵塞检查和清洗叶轮及出水口运行中电流减少1转速降低检查原动机及电源2安装高度增加检查吸水管路，吸水面3空气漏入吸水管或经机械密封进入泵内检查管路及机械密封4吸水管和压水管路阻力增加检查管路及管路中可能堵塞之外或管路过小

21、5叶轮堵塞检查和清洗叶轮6叶轮的损坏和密封环的磨损清洗过滤网7进口滤网堵塞降低吸水管端的位置8吸水管插入吸水池深度不够，带空气入泵运行中压头降低1转速降低检查原动机及电源2水中含有空气检查吸水管和机械密封3压力管损坏关小压力管阀门，并检查压力水管4叶轮损坏和密封磨损拆开修理，必要时更换原动机过热1转速高于额定转速检查原动机及电源2水泵流量大于许可流量关小压水管上阀门3原动机或水泵发生机械磨损检查原动机和水泵4水泵装配不良，转动部件与静止部件发生摩擦或卡住停泵，用手转动，找出摩擦和卡住的部件，然后加以修理或调整5三相电动机有一相保险丝烧断或电动机三相电流不平衡更换保险丝或检修电动机水泵机组发生振

22、动和噪声1装置不当检查机组连轴器和中心以及叶轮2叶轮局部堵塞检查和清洗叶轮3个别零件机械损伤更换零件4吸水管和压水管的固定装置松动拧紧固定装置5安装高度太高，发生气蚀现象停用水泵，采取措施以减少安装高度6地脚螺栓松动或基础不牢固拧紧地脚螺栓，如果基础不牢固，可加固或修理轴承发热1轴瓦接触不良或接触不适当进行检修校核2轴承磨损或松动仔细检查，进行修理和调整3油环转动不灵活，油量太少或供油中断检查或更新油环，使润滑系统畅通4转子中心不正，轴弯曲进行校正或更换油5油质不良或油内混有杂物更换油质，或将油滤过处理，清洗轴承和油室6轴承尺寸不够改造轴承管路发生水击水泵或管路中有空气放出空气，清除积聚空气的

23、原因3. 阀门类：故障现象可能原因处理措施渗漏量过大密封不良调整阀门和阀板的密封不能顺畅地起闭重合度不适当调整启闭机与闸门的重合度4. 管道类：故障现象可能原因处理措施连接处渗漏连接时未能良好密封重新套接管体泄漏管件有本质性问题更换管件管件堵塞管线内有杂物未清理出来清理管线内杂物六、水质情况1、曝气大小：保证缺氧池溶氧浓度0.5mg/L.如果超过，则关闭污水回流泵。依据进水情况测溶氧，以达到要求为准。保证溶氧的情况下尽量运行污水回流泵。进行脱氮和保证后续处理需要的碱度。好氧池前段溶氧浓度控制在3左右，末端控制在5以下，不在范围通过调节风机泄压旁通或者调整风机频率来控制，每个池子可以通过调节自己

24、的阀门来控制。一般分为进水开始、中途、结束后测溶氧。长时间不进水的话，一定要尽量多次测溶氧，防止溶氧太高。2、PH：进水前后要测缺氧池进水端和出水端PH，尽量保持在7.8左右。太高的话先分析水质，看是否进来其它水，同时关闭回流泵。长时间偏高的话，要加酸性物质来中和碱度。太低的话加大回流程度，若是还是偏低，要加碱性物质来中和酸度。出水水质PH在前段控制好的情况下，都能达标。3、进水水质均衡性：要测试缺氧池出水端COD和NH3的比列。最好控制在10:1.一般情况会偏低，需要在好氧池前段加葡糖糖或面粉来调整。加的量需要具体数据对比来确定。偏高的话需要加尿素等物质。所有进场钢材，挂有标牌，牌上印有厂标

25、、钢号、炉罐（批）号、直径等标记并附有质量证明书；无质量证明书，不得入库；经检验合格后物资设备部方可收货，如发现不合格钢材，不得验收入库。合格钢材应分批验收入库。forming the Government, enterprises and the public forces and actively participate in, sharing a strong atmosphere. Comrades, do work in the countryside and five water treatment, three to split, is related to overall de

26、velopment, responsibility, task, departments at all levels must play more than spirit, do solid work, and difficult, and efforts to promote the work to a new level, South Gate of XX beauty to make new and greater contribution to the building! Research by the County, the County Government, the conven

27、ing of this county, three, poverty and development, environmental protection, the main task is to 2016-these work arrangements. For a while, . . Gay also made an important speech, we must pay special attention to follow-up. The following, according to the citys plans and . . Comrade usual requiremen

28、ts of our work, I want to tell you three views: the first, on three last year, my County three has made certain achievements. Capital work is done using city funds . . Billion yuan, annual tasks . .%; only completion target . . Minutes, annual tasks . . rate, access to city-wide recruitment talent i

29、ntroduction . . Award recognized scientific and technological achievements . . , Cooperation of . . Innovation platforms . . Also complete tasks in the city. The overall three column in the city . . Name, did not enter the city in recognition of the results of this. This means we and other counties

30、than there is room to continue the efforts. From each town in the County Street, alland improve idle land of utilization, real achieved environment improved and productivity development mutual promoting total win. Five, firmly implement, promoting work ahead, to create highlights. Third deployment,

31、implementation of seven, then it is imperative to strengthen responsibility and improve the mechanisms and implementation. All localities and departments must be convinced that goals, going all out, mustering spirit, work together to ensure that this years objectives carry out tasks, at the forefron

32、t. First, we must strengthen the leadership to implement. Departments at all levels should always work and rural five water treatment, three to split in an important position, and carry the main responsibility, main leader personally, leaders arrested and layers of responsibility rank transmission p

33、ressure established hierarchical accountability, and work together to promote the work of the mechanism, a concerted effort pay attention to implementation. County nongban, flood, three to one down to further play a leading catch total, integrated and coordinated role of all kinds is long, Sheriff I

34、nspector to effectively fulfill their responsibilities, formed the alignment on the fire line and management a lively situation. Second, we must strengthen the test implementation of the Governor. Role play the Governor got the baton, for agricultural and rural focus and five water treatment, three

35、to split work, refine improve assessment methods and evaluation system, accurate assessment. Combined with dare play, tree benchmark style building five major operations, carry on and gain firsthand experience of supervision, in particular, to strengthen the focus on the long signs go left, names su

36、ch as supervision, urged all levels longer on duty in place. Through the supervisory assessment, to promote habits, stimulating power. Third, we must strengthen implementation style. Departments at all levels to work in rural areas and five water treatment, three to split as training cadres for majo

37、r platforms, compete against large examination room, inspection cadres work performance of the ring, water control and the Japanese pulled a workout, training, discovery and selection of cadres. Than good catch up, first to excellence-oriented. Party members and cadres at all levels must adhere to t

38、he rural, water control and the Japanese pulled a grass-roots, put down the shelf, leaned pragmatic style, the spirit of play, become a benchmark model. Four, we must strengthen propaganda implementation. Comprehensive utilization of micro-credit, micro-blogging, new media, mining, summarizing, good

39、 publicity work in the countryside and five water treatment, three to split advanced models, point to gather positive energy for the community to see the results of our work in time, increase public awareness, participation rates, satisfaction and support. Play gongqingfu, a mass organization and grass-roots such as schools, communityThe role of