YL、YLT系列高压用.doc

《YL、YLT系列高压用.doc》由会员分享，可在线阅读，更多相关《YL、YLT系列高压用.doc（13页珍藏版）》请在得力文库 - 分享文档赚钱的网站上搜索。

1、【精品文档】如有侵权，请联系网站删除，仅供学习与交流YL、YLT系列高压用.精品文档.YL、YLT系列高压三相异步电动机（机座号355630）0EE.138.119佳木斯电机股份有限公司二二年十二月一、 概述 YL、YLT系列高压三相异步电动机是我公司采用国内外先进技术，结合我公司几十年生产高压电动机的实践经验而设计制造的优化系列产品，具有结构紧凑、重量轻、高效、节能、噪声低、振动小、可靠性高、使用寿命长、安装维护方便等优点。 本系列电动机采用F级绝缘，额定频率50Hz，额定电压为3kV、6kV、10kV三种，也可按订货要求制造60Hz和其它电压的电动机。本系列电动机的功率等级，电气性能均符合

2、国家标准GB755旋转电机 定额和性能以及相关国际电工委员会IEC标准。本系列电动机各部分机械尺寸，公差符合国家标准GB/T18001804和国际标准化委员会ISO标准。根据GB/T4942.1和IEC34-5旋转电机外壳防护分级本系列电动机的外壳防护等级为IP23，如果用户需要其他防护等级如IP44及IP54等可另行协商。根据GB/T1993和IEC34-6旋转电机冷却方法的标准，本系列电动机冷却方式为IC01。如果用户需要其他冷却方法可另行协商。本系列电动机基本安装方式为立式带凸缘（IMV1）结构，符合GB/T997和IEC34-7电机结构及安装型式代号的规定。二、 型号说明YL 400

3、1 4 极数 铁心长序号 机座号 电机系列代码(YLT系列电机可承受除电机转子重量以外的附加轴向力、YL系列电机不可承受除电机转子重量以外的附加轴向力)三、 结构说明本系列电动机采用箱式结构，机座用钢板焊成箱形，重量轻、钢度好。机座两侧面开有窗孔，并安装有百叶窗，拆下后可以观察及触及电机内部，便于电机的维护和修理。定子采用滑入式外装压结构，定子绕组采用F级绝缘材料，10kV电动机采用可靠的防电晕措施，绕组端部有可靠的固定及绑扎。在制造过程中经过多次匝间脉冲电压试验及对地耐压试验，并采用真空压力浸渍无溶剂漆工艺（VPI）处理。因此，电动机的绝缘性能优良可靠，机械强度好，防潮能力强。鼠笼转子有铸铝

4、和铜条两种结构，采用先进可靠的铸铝工艺或焊接工艺制造而成，并经过动平衡校验，因此电动机运行平稳可靠。轴承防护等级为IP44，也可按需要提高为IP54。主接线盒防护等级为IP54，主出线盒内、外均有单独的接地端子。根据用户要求，可在定子绕组、轴承等重要部位加设测温装置，便于现场观察和远距离监控，以保证电动机安全可靠地运行。四、 用途电动机可用于躯动立式水泵等立式机械，YL系列电机不承受除电机转子重量以外的附加轴向力。YLT系列电机可承受除电机转子重量以外的附加轴向力。中心高H允许向下推力范围kN355450605005606015063060200五、 电动机的起动1 用户的电网应保证电动机在起

5、动过程中的电机端电压不低于额定电压的85%。2 被传动机械的阻力矩特性为水泵类阻力矩特性。在上述条件下，电动机允许在实际冷状态下连续起动两次或者在电机热状态下起动一次，电机在两次起动之间为自然停车，额外的再次起动电机应在停车4小时以后。如果需要驱动的机械为非水泵类立式机械，务请事先和制造厂联系协商以便特殊设计，保障电机的可靠运行。六、 订货注意事项：请在订货时注明以下参数（举例如下）：电动机型号 YL4004-4额定功率 500kW额定电压 6kV极数 4旋转方向 顺时针转向（面对电机轴伸端看）防护等级 IP23冷却方式 IC01安装方式 IMV1额定频率 50Hz环境条件 海拔1000m 环

6、境温度-10+401其他特殊要求，需另订技术协议后方可签定订货合同。未注明旋转方向时，按顺时针处理。2随着产品的技术进步和国内外有关标准的修订，样本内技术参数如有变动，恕不另行通知。七、技术数据（保证值）1、YL、YLT系列高压三相异步电动机（6kV） 表1 YL系列电动机技术数据（保证值） 型号额定功率(kW)定子电流(A)额定转速(r/min)效率(%)功率因数cos最大转矩额定转矩堵转转矩额定转矩堵转电流额定电流电机Jm(kg.m2)重量（kg）YL3551-418522.8147793.10.841.80.86.52.51950YL3552-420024.6147793.20.841.

7、80.86.52.71980YL3553-422026.7147793.30.851.80.86.53.02010YL3554-425030.3147893.40.851.80.86.53.52040YL3555-428033.5147893.50.861.80.86.53.82090YL3556-431537.7147893.60.861.80.86.54.02130YL4001-435542.3148593.80.861.80.86.55.82620YL4002-440047.6148594.00.861.80.86.56.02700YL4003-445053.5148594.20.861

8、.80.86.56.52800YL4004-450058.6148594.30.871.80.86.57.02890YL4005-456065.5148594.50.871.80.86.58.03010YL4501-463073.5148594.80.871.80.86.511.03160YL4502-471082.7148595.00.871.80.86.512.03300YL4503-480093.0148695.10.871.80.86.513.03440YL4504-4900104.6148795.20.871.80.86.514.03580YL5001-41000116.114859

9、5.30.871.80.76.524.04400YL5002-41120128.4148595.40.881.80.76.526.04500YL5003-41250143.1148595.50.881.80.76.530.04600YL5004-41400160.1148695.60.881.80.76.532.04800YL3553-618523.798792.60.811.80.86.05.22060YL3554-620025.698792.80.811.80.86.05.62100YL3555-622027.898793.00.821.80.86.06.02140YL3556-62503

10、1.498793.30.821.80.86.07.02170YL4002-628034.798893.50.831.80.86.010.02590YL4003-631539.098893.70.831.80.86.011.02690YL4004-635543.898893.90.831.80.86.011.52770 表1 YL系列电动机技术数据（保证值）（续）型号额定功率kW定子电流A额定转速r/min效率%功率因数cos最大转矩额定转矩堵转转矩额定转矩堵转电流额定电流电机Jmkg.m2重量kgYL4005-640049.398894.00.831.80.86.012.02980YL4501

11、-645054.798894.30.841.80.86.015.03110YL4502-650059.998894.50.851.80.86.016.03240YL4503-656066.998894.70.851.80.86.017.03370YL4504-663075.298994.80.851.80.86.020.03490YL5001-671084.699095.00.851.80.76.032.04100YL5002-680095.398995.10.851.80.76.034.04200YL5003-6900107.098995.20.851.80.76.040.04500YL50

12、04-61000118.898995.30.851.80.76.047.04700YL5601-61120131.499095.40.861.80.76.570.06185YL5602-61250146.599095.50.861.80.76.575.06415YL5603-61400163.999095.60.861.80.76.582.06670YL6301-61600187.199195.70.861.80.76.5117.09300YL6302-61800210.299195.80.861.80.76.5132.09720YL6303-62000233.399195.90.861.80

13、.76.5143.010550YL4001-818525.074192.60.771.80.85.59.02480YL4002-820026.674192.80.781.80.85.510.02570YL4003-822029.274192.90.781.80.85.511.02650YL4004-825032.774193.00.791.80.85.512.02760YL4005-828036.674193.20.791.80.85.513.02890YL4501-831540.674293.40.801.80.85.516.03140YL4502-835545.774293.50.801.

14、80.85.517.03290YL4503-840051.374293.70.801.80.85.518.03340YL4504-845057.074293.80.811.80.85.519.03470YL5001-850063.074294.30.811.80.85.530.04000YL5002-856069.674294.40.821.80.85.534.04150YL5003-863078.274394.50.821.80.85.538.04350YL5004-871088.174494.60.821.80.85.542.04500YL5601-880096.874394.70.841

15、.80.76.087.06130YL5602-8900108.874394.80.841.80.76.092.06325YL5603-81000120.774394.90.841.80.76.01026473YL6301-81120135.174495.00.841.80.76.01379620YL6302-81250150.674495.10.841.80.76.015110200YL6303-81400168.574495.20.841.80.76.016010570YL6304-81600192.374495.30.841.80.76.016810920YL4004-1018525.95

16、9391.70.751.80.85.511.02760YL4005-1020027.959391.90.751.80.85.512.02890YL4501-1022029.959292.10.771.80.85.519.03060YL4502-1025033.459292.30.781.80.85.520.03140YL4503-1028037.359292.50.781.80.85.522.03270YL4504-1031541.459292.60.791.80.85.524.03330YL4505-1035546.659292.80.791.80.85.525.03450YL5001-10

17、40051.659293.30.801.80.85.536.04000表1 YL系列电动机技术数据（保证值）（续）型 号额定功率kW定子电流A额定转速r/min效率%功率因数cos最大转矩额定转矩堵转转矩额定转矩堵转电流额定电流电机Jmkg.m2重量kgYL5002-1045058.059393.40.801.80.85.538.04150YL5003-1050064.359493.60.801.80.85.542.04300YL5004-1056071.959493.70.801.80.85.545.04450YL5005-1063080.859593.80.801.80.85.552.04

18、650YL5601-1071088.659394.00.821.80.76.079.06160YL5602-1080099.759394.20.821.80.76.088.06360YL5603-10900112.059394.30.821.80.76.093.06570YL6301-101000124.359494.40.821.80.76.01409620YL6302-101120138.959494.60.821.80.76.015210200YL6303-101250154.759494.80.821.80.76.016710570YL6304-101400173.159494.90.

19、821.80.76.0175.010930YL4502-1218527.249490.90.721.80.85.519.03170YL4503-1220029.349491.10.721.80.85.521.03260YL4504-1222031.749491.40.731.80.85.524.03340YL4505-1225035.949491.70.731.80.85.526.03410YL5001-1228039.349392.70.741.80.85.540.04000YL5002-1231543.649392.80.751.80.85.542.04100YL5003-1235549.

20、049493.00.751.80.85.543.04250YL5004-1240055.049493.30.751.80.85.547.04400YL5005-1245061.849593.40.751.80.85.550.04550YL5601-1250065.049593.70.791.80.76.0103.06160YL5602-1256072.749593.80.791.80.76.0114.06360YL5603-1263081.749593.90.791.80.76.0127.06570YL6301-1271092.049594.00.791.80.76.0191.09600YL6

21、302-12800103.449594.20.791.80.76.0208.010050YL6303-12900116.249594.30.791.80.76.0227.010450YL6304-121000129.049594.40.791.80.76.0239.010820表2 YLT系列电动机技术数据（保证值）型号额定功率kW定子电流A额定转速r/min效率%功率因数cos最大转矩额定转矩堵转转矩额定转矩堵转电流额定电流电机Jmkg.m2重量kgYLT3553-618523.798792.60.811.80.86.05.22060YLT3554-620025.698792.80.811.

22、80.86.05.62100YLT3555-622027.898793.00.821.80.86.06.02140YLT3556-625031.498793.30.821.80.86.07.02170YLT4002-628034.798893.50.831.80.86.010.02590YLT4003-631539.098893.70.831.80.86.011.02690YLT4004-635543.898893.90.831.80.86.011.52770YLT4005-640049.398894.00.831.80.86.012.02980YLT4501-645054.798894.30

23、.841.80.86.015.03110YLT4502-650059.998894.50.851.80.86.016.03240YLT4503-656066.998894.70.851.80.86.017.03370YLT4504-663075.298994.80.851.80.86.020.03490YLT5001-671084.699095.00.851.80.76.032.04100YLT5002-680095.398995.10.851.80.76.034.04200YLT5003-6900107.098995.20.851.80.76.040.04500YLT5004-6100011

24、8.898995.30.851.80.76.047.04700YLT5601-61120131.499095.40.861.80.76.570.06185YLT5602-61250146.599095.50.861.80.76.575.06415YLT5603-61400163.999095.60.861.80.76.582.06670YLT6301-61600187.199195.70.861.80.76.5117.09300YLT6302-61800210.299195.80.861.80.76.5132.09720YLT6303-62000233.399195.90.861.80.76.

25、5143.010550YLT4001-818525.074192.60.771.80.85.59.02480YLT4002-820026.674192.80.781.80.85.510.02570YLT4003-822029.274192.90.781.80.85.511.02650YLT4004-825032.774193.00.791.80.85.512.02760YLT4005-828036.674193.20.791.80.85.513.02890YLT4501-831540.674293.40.801.80.85.516.03140YLT4502-835545.774293.50.8

26、01.80.85.517.03290YLT4503-840051.374293.70.801.80.85.518.03340YLT4504-845057.074293.80.811.80.85.519.03470YLT5001-850063.074294.30.811.80.85.530.04000YLT5002-856069.674294.40.821.80.85.534.04150YLT5003-863078.274394.50.821.80.85.538.04350YLT5004-871088.174494.60.821.80.85.542.04500YLT5601-880096.874

27、394.70.841.80.76.087.06130YLT5602-8900108.874394.80.841.80.76.092.06325YLT5603-81000120.774394.90.841.80.76.01026473YLT6301-81120135.174495.00.841.80.76.01379620YLT6302-81250150.674495.10.841.80.76.015110200YLT6303-81400168.574495.20.841.80.76.016010570YLT6304-81600192.374495.30.841.80.76.016810920Y

28、LT4004-1018525.959391.70.751.80.85.511.02760表2 YLT系列电动机技术数据（保证值）（续）型 号额定功率kW定子电流A额定转速r/min效率%功率因数cos最大转矩额定转矩堵转转矩额定转矩堵转电流额定电流电机Jmkg.m2重量kgYLT4005-1020027.959391.90.751.80.85.512.02890YLT4501-1022029.959292.10.771.80.85.519.03060YLT4502-1025033.459292.30.781.80.85.520.03140YLT4503-1028037.359292.50.78

29、1.80.85.522.03270YLT4504-1031541.459292.60.791.80.85.524.03330YLT4505-1035546.659292.80.791.80.85.525.03450YLT5002-1045058.059393.40.801.80.85.538.04150YLT5003-1050064.359493.60.801.80.85.542.04300YLT5004-1056071.959493.70.801.80.85.545.04450YLT5005-1063080.859593.80.801.80.85.552.04650YLT5001-10400

30、51.659293.30.801.80.85.536.04000YLT5601-1071088.659394.00.821.80.76.079.06160YLT5602-1080099.759394.20.821.80.76.088.06360YLT5603-10900112.059394.30.821.80.76.093.06570YLT6301-101000124.359494.40.821.80.76.01409620YLT6302-101120138.959494.60.821.80.76.015210200YLT6303-101250154.759494.80.821.80.76.0

31、16710570YLT6304-101400173.159494.90.821.80.76.0175.010930YLT4502-1218527.249490.90.721.80.85.519.03170YLT4503-1220029.349491.10.721.80.85.521.03260YLT4504-1222031.749491.40.731.80.85.524.03340YLT4505-1225035.949491.70.731.80.85.526.03410YLT5001-1228039.349392.70.741.80.85.540.04000YLT5002-1231543.64

32、9392.80.751.80.85.542.04100YLT5003-1235549.049493.00.751.80.85.543.04250YLT5004-1240055.049493.30.751.80.85.547.04400YLT5005-1245061.849593.40.751.80.85.550.04550YLT5601-1250065.049593.70.791.80.76.0103.06160YLT5602-1256072.749593.80.791.80.76.0114.06360YLT5603-1263081.749593.90.791.80.76.0127.06570

33、YLT6301-1271092.049594.00.791.80.76.0191.09600YLT6302-12800103.449594.20.791.80.76.0208.010050YLT6303-12900116.249594.30.791.80.76.0227.010450YLT6304-121000129.049594.40.791.80.76.0239.0108202YL、YLT系列高压三相异步电动机（10kV）表3 YL系列电动机技术数据（保证值）型号额定功率kW定子电流A额定转速r/min效率%功率因数cos最大转矩额定转矩堵转转矩额定转矩堵转电流额定电流电机Jmkg.m2重

34、量kgYL4501-422016.3147792.50.841.80.77.09.02550YL4502-425018.5147792.70.841.80.77.09.52645YL4503-428020.5147892.90.851.80.77.010.22710YL4504-431523.0147893.10.851.80.77.010.82790YL4505-435525.5147893.30.861.80.77.012.02850YL4506-440028.7148093.50.861.80.77.012.52915YL4507-445032.2148293.90.861.80.77.012.93180YL4508-450035.7148594.00.861.80.77.013.43315YL4509-456039.9148594.20.861.80.77.013.83